Jump to content

KH-7 Gambit

From Wikipedia, the free encyclopedia

This is an old revision of this page, as edited by 4throck (talk | contribs) at 00:39, 17 January 2024 (→See also). The present address (URL) is a permanent link to this revision, which may differ significantly from the current revision.

A KH-7 launch on Atlas-Agena.

BYEMAN codenamed GAMBIT, the KH-7 (Air Force Program 206) was a reconnaissance satellite used by the United States from July 1963 to June 1967. Like the older CORONA system, it acquired imagery intelligence by taking photographs and returning the undeveloped film to earth. It achieved a typical ground-resolution of 0.61 m (2 ft 0 in) to 0.91 m (3 ft 0 in).[1] Though most of the imagery from the KH-7 satellites was declassified in 2002, details of the satellite program (and the satellite's construction) remained classified until 2011.[2]

In its summary report following the conclusion of the program, the National Reconnaissance Office concluded that the GAMBIT program was considered highly successful in that it produced the first high-resolution satellite photography, 69.4% of the images having a resolution under 0.91 m (3 ft 0 in); its record of successful launches, orbits, and recoveries far surpassed the records of earlier systems; and it advanced the state of the art to the point where follow-on larger systems could be developed and flown successfully. The report also stated that Gambit had provided the intelligence community with the first high-resolution satellite photography of denied areas, the intelligence value of which was considered "extremely high".[1] In particular, its overall success stood in sharp contrast to the two first-generation photoreconnaissance programs, Corona, which suffered far too many malfunctions to achieve any consistent success, and SAMOS, which was essentially a complete failure with all satellites either being lost in launch mishaps or returning no usable imagery.

GAMBIT emerged in 1962 as an alternative to the less-than-successful CORONA and the completely failed SAMOS, although CORONA was not cancelled and in fact continued operating alongside the newer program into the early 1970s. While CORONA used the Thor-Agena launch vehicle family, GAMBIT would be launched on Atlas-Agena, the booster used for SAMOS. After the improved KH-8 GAMBIT-3 satellite was developed during 1965, operations shifted to the larger Titan IIIB launch vehicle.

System configuration

A KH-7 GAMBIT-1 launch configuration (with Agena D service module).
A KH-7 GAMBIT-1 on-orbit configuration (w/o Agena D service module).
A GAMBIT Reconnaissance System.
A KH-7 GAMBIT in launch configuration on display at the National Museum of the United States Air Force in Dayton, Ohio.

Each GAMBIT-1 satellite was about 4.5 m (15 ft) long, 1.5 m (4 ft 11 in) wide, weighed about 523 kg (1,153 lb), and carried about 914 m (2,999 ft) of film.[3]

A feasibility study for the Geodetic Orbital Photographic Satellite System reveals three subsystems for U.S. optical reconnaissance satellites in the 1960s: the Orbital (or Orbiting) Control Vehicle (OCV), the Data Collection Module (DCM), and the Recovery Section (RS).[4] For the KH-7, the DCM is also called the Camera Optics Module (COM), and is integrated in the OCV, which has a length of 5.5 m (18 ft) and a diameter of 1.52 m (5 ft 0 in).[5]

Camera Optics Module

The Camera Optics Module of KH-7 consists of three cameras: a single strip camera, a stellar camera, and an index camera.

In the strip camera the ground image is reflected by a steerable flat mirror to a 1.21 m (4 ft 0 in) diameter stationary concave primary mirror. The primary mirror reflects the light through an opening in the flat mirror and through a Ross corrector. It took images of a 6.3° wide ground swath by exposing a 22 cm (8.7 in) wide moving portion of film through a small slit aperture.[6][7] The initial ground resolution of the satellite was 1.2 m (3 ft 11 in), but improved to 0.6 m (2 ft 0 in) by 1966. Each satellite weighed about 2,000 kg (4,400 lb), and returned a single film bucket per mission. The camera and film transport system were manufactured by Eastman Kodak Company.[7]

The index camera is a copy of cameras systems previously used in the KH-4 and KH-6 satellites, and takes exposures of Earth in direction of the vehicle roll position for attitude determination. The stellar camera takes images of star fields with a reseau grid being superimposed on the image plane.[6] The S/I camera was provided by Itek, and horizon sensors were provided by Barnes Engineering Co.[1]

Orbital Control Vehicle and Recovery Vehicle

A film capsule being retrieved.

The primary contractor for the Orbital Control Vehicle and the Recovery Vehicle was General Electric.[1] Films were to be retrieved mid-air by a C-130 Hercules specially outfitted for that purpose.[8]

Mission

All KH-7 satellites were launched from Point Arguello, which became part of Vandenberg Air Force Base in July 1964. KH-7 satellites flew 38 missions, numbered 4001-4038, of which 34 returned film, and of these, 30 returned usable imagery. Mission duration was 1 to 8 days.[9] KH-7 satellites logged a total of almost 170 operational days in orbit.[1]

Functionality

A KH-7 image of the Chinese Shuanchengtzu Missile Center A, May 1967.

A high-resolution instrument, the KH-7 took detailed pictures of "hot spots" and most of its photographs are of Chinese and Soviet nuclear and missile installations, with smaller amounts of coverage of cities and harbors.[10] Most of the imagery from this camera, amounting to 19,000 images, was declassified in 2002 as a result of Executive order 12951,[11] the same order which declassified CORONA, and copies of the films were transferred to the U.S. Geological Survey's Earth Resources Observation Systems office.[12] Approximately 100 frames covering the state of Israel remain classified.[13]

In early 1964, the CIA toyed with the idea of using GAMBIT to photograph military installations in Cuba, but this was dismissed as unworkable as the satellites were primarily designed with higher-latitude Soviet territory in mind and because it would mean wasting an entire satellite on the Latin America-Caribbean area which had little else of interest to U.S. intelligence services. It was decided that U-2 spyplane flights were more-than-adequate to provide coverage of Cuban activity.

ELINT subsatellite

Mission 4009 included an ELINT P-11 subsatellite for radar monitoring, which was launched into a higher orbit.[14][15]

List of launches

A KH-7 GAMBIT optical reconnaissance satellite.
Name Mission No. Launch Date Alt. Name NSSDC ID No. Launch Vehicle Perigee (km) Apogee (km) Inclination (deg)
KH7-1 4001 1963-07-12 OPS-1467 1963-028A Atlas-Agena D 164 164 95.4
KH7-2 4002 1963-09-06 OPS-1947 1963-036A Atlas Agena D 168 263 94.4
KH7-3 4003 1963-10-25 OPS-2196 1963-041A Atlas Agena D 144 332 99.1
KH7-4 4004 1963-12-18 OPS-2372 1963-051A Atlas Agena D 122 266 97.9
KH7-5 4005 1964-02-25 OPS-2423 1964-009A Atlas Agena D 173 190 95.7
KH7-6 4006 1964-03-11 OPS-3435 1964-012A Atlas Agena D 163 203 95.8
KH7-7 4007 1964-04-23 OPS-3743 1964-020A Atlas Agena D 150 366 103.6
KH7-8 4008 1964-05-19 OPS-3592 1964-024A Atlas Agena D 141 380 101.1
KH7-9 4009 1964-07-06 OPS-3684 1964-036A Atlas Agena D 121 346 92.9
KH7-10 4010 1964-08-14 OPS-3802 1964-045A SLV-3 Agena D 149 307 95.5
KH7-11 4011 1964-09-23 OPS-4262 1964-058A SLV-3 Agena D 145 303 92.9
KH7-12 4012 1964-10-08 OPS-4036 1964-F11 SLV-3 Agena D --- --- ---
KH7-13 4013 1964-10-23 OPS-4384 1964-068A Atlas Agena D 139 271 88.6
KH7-14 4014 1964-12-04 OPS-4439 1964-079A SLV-3 Agena D 158 357 97
KH7-15 4015 1965-01-23 OPS-4703 1965-005A SLV-3 Agena D 146 291 102.5
KH7-16 4016 1965-03-12 OPS-4920 1965-019A SLV-3 Agena D 93 155 0.0
KH7-17 4017 1965-04-28 OPS-4983 1965-031A SLV-3 Agena D 180 259 95.7
KH7-18 4018 1965-05-27 OPS-5236 1965-041A SLV-3 Agena D 149 267 95.8
KH7-19 4019 1965-06-25 OPS-5501 1965-050B SLV-3 Agena D 151 283 107.6
KH7-20 4020 1965-07-12 OPS-5810 1965-F07 SLV-3 Agena D --- --- ---
KH7-21 4021 1965-08-03 OPS-5698 1965-062A SLV-3 Agena D 149 307 107.5
KH7-22 4022 1965-09-30 OPS-7208 1965-076A SLV-3 Agena D 98 164 95.6
KH7-23 4023 1965-11-08 OPS-6232 1965-090B SLV-3 Agena D 145 277 93.9
KH7-24 4024 1966-01-19 OPS-7253 1966-002A SLV-3 Agena D 150 269 93.9
KH7-25 4025 1966-02-15 OPS-1184 1966-012A SLV-3 Agena D 148 293 96.5
KH7-26 4026 1966-03-18 OPS-0879 1966-022A SLV-3 Agena D 162 208 101
KH7-27 4027 1966-04-19 OPS-0910 1966-032A SLV-3 Agena D 139 312 116.9
KH7-28 4028 1966-05-14 OPS-1950 1966-039A SLV-3 Agena D 133 358 110.5
KH7-29 4029 1966-06-03 OPS-1577 1966-048A SLV-3 Agena D 143 288 86.9
KH7-30 4030 1966-07-12 OPS-1850 1966-062A SLV-3 Agena D 137 236 95.5
KH7-31 4031 1966-08-16 OPS-1832 1966-074A SLV-3 Agena D 146 358 93.3
KH7-32 4032 1966-09-16 OPS-1686 1966-083A SLV-3 Agena D 148 333 93.9
KH7-33 4033 1966-10-12 OPS-2055 1966-090A SLV-3 Agena D 155 287 91
KH7-34 4034 1966-11-02 OPS-2070 1966-098A SLV-3 Agena D 159 305 91
KH7-35 4035 1966-12-05 OPS-1890 1966-109A SLV-3 Agena D 137 388 104.6
KH7-36 4036 1967-02-02 OPS-4399 1967-007A SLV-3 Agena D 136 357 102.4
KH7-37 4037 1967-05-22 OPS-4321 1967-050A SLV-3 Agena D 135 293 91.5
KH7-38 4038 1967-06-04 OPS-4360 1967-055A SLV-3 Agena D 149 456 104.8

(NSSDC ID Numbers: See COSPAR)

History

An enlargement of a photograph of the U.S. Capitol taken by KH-7 mission 4025 on 19 February 1966.
A KH-7 GAMBIT optical reconnaissance satellite.
Section source: Space Review[7]

GAMBIT marked the first use of next-generation launch vehicle systems as Convair and Lockheed, the builders of the Atlas-Agena booster, began introducing improved, standardized launchers to replace the multitude of customized variants used up to 1963, which caused endless mix ups, poor reliability, and mission failures. This followed a recommendation by the Lewis Spaceflight Center in Cleveland, Ohio that Atlas and Agena switch to one standard configuration for both NASA and Air Force launches, with uniform testing and checkout procedures, as well as improved materials and fabrication processes for the various hardware components in the boosters. The Agena D, a standardized Agena B, arrived first, with the uprated Atlas SLV-3 taking another year to fly. The first eight GAMBIT flown still used custom-modified Atlas D ICBM cores, with GAMBIT 4010 in August 1964 being the first use of the SLV-3. Afterwards, all GAMBIT used SLV-3s aside from 4013, which used the last old-style Atlas remaining in the inventory.

In early 1963, the GAMBIT program began with failures. On 11 May 1963, the first GAMBIT satellite sat atop Atlas-Agena 190D on SLC-4W at Vandenberg Air Force Base awaiting launch. An air bubble formed while loading LOX into the booster and as soon as propellant filling was stopped, the bubble damaged the fill/drain valve. This quickly caused both the LOX and helium pressure gas to escape from the tank, depressurizing the Atlas's balloon skin and causing the entire launch vehicle to crumple to the ground. The RP-1 tank ruptured and spilled its contents onto the pad. There was no fire or explosion, but the Agena sustained minor damage and the satellite a considerable amount as the cameras were crushed in by impact with the ground and had their lenses destroyed. The pad itself was undamaged except for a steel beam cracked by exposure to the super-chilled LOX, which was repaired in two days. Fortunately, the satellite on the booster was not the same one planned for the actual launch and the payload shroud had also remained in one piece, preventing any unauthorized parties from seeing the GAMBIT. Secrecy surrounding the program was strict and knowledge of GAMBIT limited only to those directly involved in the program. While the early CORONA and SAMOS flights had been merely billed to the public as scientific missions, it became increasingly difficult to explain why they failed to return any scientific data. In late 1961, President John F. Kennedy ordered a veil of secrecy placed around the photoreconnaissance program and by GAMBIT's debut in 1963, DoD announcements described no details other than the launching of a "classified payload".

The Agena was sent back to Lockheed for repairs and a different Atlas (vehicle 201D) was used, and the first successful GAMBIT mission was launched on 12 July 1963. The launch vehicle performed perfectly and inserted GAMBIT into polar orbit with a 189 km (117 mi) altitude. The Air Force designated this mission number 4001.

Aerospace Corporation recommended that, during GAMBIT's first flights, the Orbital Control Vehicle (OCV) should remain attached to the Agena. This was a proven successful process for other Agena tests; and whereas the OCV was not. This decision limited GAMBIT's functionality, meaning that photographs could only be taken of targets directly below the vehicle. Once the successful photographic phase of the mission 4002 was completed, the OCV and the Agena were separated and the reentry vehicle would come down into the ocean northwest of Hawaii. The re-entry vehicle was caught in mid-air with a C-130 Hercules aircraft using a modified version of the Fulton surface-to-air recovery system. The film canister was then immediately transported to Eastman Kodak's Hawkeye facility in Rochester, New York for processing.[16] The developed results was sent to US Air Force imagery research analysts in Washington, DC.

GAMBIT mission 4003, was launched on 25 October 1963. The film canister was again ejected successfully after the photographic phase and the capsule recovered by an aircraft. Other tests were carried out with the OCV.

GAMBIT mission 4004 was launched and its film canister recovered on 18 December 1963. Missions 4005 through 4007 were also successful.

In May 1964, mission 4008 suffered major problems when the Agena did an unexplained roll during the boost phase. Even with OCV system problems, the film canister was able to return some imagery.

A variety of problems occurred with many of the remaining missions including poor or no imagery. Many of these difficulties were caused by the unreliable wire recording system carried by the GAMBITs (tape recorders were not yet in widespread use in the mid-1960s). Two satellites ended up in the Pacific Ocean. The first of them was 4012, launched on October 8, 1964. The Agena engine shut down after 1.5 seconds of operation and the GAMBIT did not attain orbit. An investigation of the failure found that an electrical short occurred in an engine relay box, resulting in a cutoff signal being issued 0.4 seconds after ignition. As soon as the engine arming command was stopped at 1.5 seconds, the Agena propulsion system shut down. Examination of factory records for the Agena found that a pair of metal screws from a little-used terminal connector had broken off and disappeared to parts unknown; it was speculated that they landed somewhere as to cause a short. Telemetry data indicated otherwise entirely normal performance of all Agena systems. The other failure was 4020, launched on 12 July 1965 when the Atlas programmer accidentally issued simultaneous SECO and BECO commands, the resultant propulsion system shutdown sending the launch vehicle into the Pacific Ocean some 1,090 km (680 mi) downrange. The latter was the first flight witnessed by newly arrived Brig. Gen John L. Martin who replaced Maj. Gen Robert Greer as head of the KH-7 program. Martin cracked down and began demanding higher workmanship and quality standards. He is credited with having significantly improved the success rate of the program.

It was noted that the GAMBIT flights through the first half of 1964 had been mostly successful, but a string of malfunctions occurred starting in the second half of the year and continuing through the first half of 1965. These included the two above-mentioned launch failures plus GAMBIT 4013 which did not return any imagery and GAMBIT 4014 which suffered a battery explosion. GAMBIT 4019 did not return any imagery either. Eventually, it was determined that the culprit was an extra structure added to the SLC-4W umbilical tower that sent resonant vibration through the Atlas-Agena stack at liftoff, jarring random components in the booster and/or spacecraft loose.

The KH-7 GAMBIT was an overall success, even with some failures; thus providing National Reconnaissance Office and the President with quality intelligence collection. Following KH-7 projects had greatly improved major upgrades in the spacecraft and its camera systems.

Cost

The total cost of the 38 flight KH-7 program from FY1963 to FY1967, without non-recurring costs, and excluding five GAMBIT cameras sold to NASA, was US$651.4 million in 1963 dollars (inflation adjusted US$ 6.48 billion present day).[17] Non-recurring costs for industrial facilities, development, and one-time support amounted to 24.3% of the total program cost, or US$209.1 million. The resulting total program costs were US$860.5 million in 1963 dollars (inflation adjusted US$ 8.56 billion present day).[1]

Other U.S. imaging spy satellites

See also

Wikimedia Commons has media related to KH-7 GAMBIT.

References

  1. ^ a b c d e f "Summary Analysis of Program 206 (GAMBIT)" (PDF). National Reconnaissance Office. 29 August 1967. Archived from the original (PDF) on 17 October 2011. Retrieved 7 October 2011. Public Domain This article incorporates text from this source, which is in the public domain.
  2. ^ Flashlights in the dark, The Space Review
  3. ^ "Declassified U.S. Spy Satellites from Cold War Land in Ohio". Space.com. 28 January 2012. Retrieved 11 October 2015.
  4. ^ "Feasibility Study Final Report: Geodetic Optical Photographic Satellite System, Volume 2 Data Collection System" (PDF). National Reconnaissance Office. June 1966. Archived from the original (PDF) on 12 December 2013. Retrieved 19 December 2010.
  5. ^ Day, Dwayne A. (29 November 2010). "Black Apollo". thespacereview.com. Retrieved 17 December 2010.
  6. ^ a b "KH-7 Camera System- Part I". National Photographic Interpretation Center. July 1963. Archived from the original on 15 September 2012. Retrieved 26 September 2011.
  7. ^ a b c Day, Dwayne A. (29 November 2010). "Ike's gambit: The development and operations of the KH-7 and KH-8 spy satellites". thespacereview.com. Retrieved 25 January 2009.
  8. ^ "Key Hole (KH)". Retrieved 4 November 2015.
  9. ^ "NRO review and redaction guide (2006 ed.)" (PDF). National Reconnaissance Office.
  10. ^ NARA ARC Archived 1 May 2017 at the Wayback Machine database description of "Keyhole-7 (KH-7) Satellite Imagery, 07/01/1963 - 06/30/1967", accession number NN3-263-02-011
  11. ^ "National Archives Releases Recently Declassified Satellite Imagery". National Archives and Records Administration press release. 9 October 2002. Public Domain This article incorporates text from this source, which is in the public domain.
  12. ^ edc.usgs.gov Archived 2007-06-30 at the Wayback Machine
  13. ^ "Historical imagery declassification". National Geospatial-Intelligence Agency. Archived from the original on 7 October 2007. Public Domain This article incorporates text from this source, which is in the public domain.
  14. ^ "1964-036B". NASA. 8 October 2010. Public Domain This article incorporates text from this source, which is in the public domain.
  15. ^ Day, Dwayne (27 April 2009). "Robotic ravens: American ferret satellite operations during the Cold War". The Space Review.
  16. ^ "National Reconnaissance Office Review and Redaction Guide: Appendix C - Glossary of Code Words and Terms" (PDF). National Reconnaissance Office. 2008.[permanent dead link‍] Public Domain This article incorporates text from this source, which is in the public domain.
  17. ^ "The GAMBIT story". National Reconnaissance Office. June 1991. Archived from the original on 7 October 2017. Retrieved 25 September 2011. Public Domain This article incorporates text from this source, which is in the public domain.
Retrieved from "https://en.wikipedia.org/enwiki/w/index.php?title=KH-7_Gambit&oldid=1196276794"