NIR 80 Class

Not to be confused with British Rail Class 80.

Northern Ireland Railways Class 80
80 Class power car No. 69 in preservation at the Downpatrick and County Down Railway
In service	1974 – 2011 (Passenger) 2006 – 2017 (Sandite)
Manufacturer	British Rail Engineering Limited
Family name	Mark 2
Number built	22 power cars 20 intermediates 26 driving trailers
Formation	2, 3, 4 or 6 cars per set
Capacity	Variable depending on trailer capacity, most 3 car sets up to 210 passengers
Operators	Northern Ireland Railways
Lines served	Belfast-Derry Belfast-Bangor Belfast-Newry Belfast-Larne Coleraine-Portrush Lisburn-Antrim (Until 2003)
Specifications
Maximum speed	70 mph (113 km/h)
Prime mover(s)	English Electric 4SRKT
Safety system(s)	AWS, TPWS
Track gauge	Irish gauge – 1,600 mm (5 ft 3 in)

The Class 80 is a type of diesel electric multiple unit formerly used by Northern Ireland Railways. They were affectionately nicknamed 'Thumpers' by rail enthusiasts due to the thumping noise their engines produced.

History

By the early 1970s the MEDs and units inherited from the Great Northern Railway (GNR) had been in service for 20 years, and the MPDs for 10 years. To replace these increasingly life-expired units, Northern Ireland Railways (NIR) placed an order with British Rail Engineering Limited (BREL) for 9 new DMUs. These were to be built as four 3-car and five 2-car sets and were delivered in 1974/75. Structurally, the new trains were based on the British Rail Mark 2b bodyshell, which NIR was already using for the Enterprise service. The new trains were classified as the Class 80.

The power cars were fitted with an English Electric 560 HP diesel engine, with electric transmission to two traction motors mounted on the rear bogie. The seating capacity of the power cars was 45, however after providing for wheelchair accommodation, this was reduced to 42. The vehicle also incorporated a guards/parcel compartment. The intermediate coaches were fitted with an additional door on each side to aid passenger flow and had a capacity of 87. The driving trailers had a small cab built at one end, which necessitated the removal of six seats. This cab was set to the left to preserve the gangway connection, so that two train sets could be coupled together and still allow passengers to travel between the trains. All three types are of integral construction, however the power cars, because of their weight, also have an underframe. They were similar to the UTA 70 Class, both mechanically and electrically.

The Class 80 was intended to replace the aging MED, MPD and ex-GNR AEC and BUT railcars on the NCC services and the suburban service between Bangor and Portadown. The railcars proved so successful that a second series was ordered in 1975, entering service in 1977/78.

Each vehicle was numbered individually, with power car numbers running from 67 to 69, and 81 to 99. The Intermediate Trailers were numbered 761 to 780 and the Driving Trailers were numbered 731 to 756. Power cars 81 to 89 were built between 1974/1975, while 67 to 69 and 90 to 99 were built between 1978/1979. Intermediate Trailers 761 to 764 were also built between 1974/1975, with 765 to 773 being completed between 1978/1979. Likewise, the Driving Trailers were also completed in batches, with 731 to 739 built between 1974/1975 and 740 to 751 built between 1978/1979. The additional coaches were conversions from BR or old NI Railways loco-hauled coaches, and were not original Class 80 vehicles. These were Driving Trailers 752 to 756 and Intermediate Trailers 774 to 780. During the mid-1990s the surviving vehicles were all renumbered by Translink, by adding 8000 to their numbers to avoid duplication with the bus fleet operated by Ulsterbus and Citybus, also Translink subsidiaries.

Use by Iarnród Éireann

An unidentified 80 class set carrying the then Iarnród Éireann logo at Dún Laoghaire in 1988.

Three 3-car sets were leased by Iarnród Éireann (IÉ) from NIR in October 1987 for use on, respectively, the Bray–Greystones shuttle (previously operated by a push–pull set rebuilt from CIÉ 2600 Class railcars), the Dublin Connolly–Maynooth route, and the Cork–Cobh line. They were originally intended as a short-term measure until Mark 3 push–pull sets became available. The sets entered service on 2 November. In addition to their regular services, they were employed on a variety of other workings, including a nine-car All-Ireland hurling special from Cork to Dublin. However, although the sets were fitted with Continuous Automatic Warning System and IÉ train radio in March 1990 and "for a while it appeared as if the units were going to be purchased by [IÉ]," NIR required them back when the lease expired at the end of October 1990. A brief "stay of execution" for the Greystones shuttle lasted until 26 November.

Refurbishment

8082 at Belfast Central (2004)

8090 at Helen's Bay (2015)

8069 at Lisburn (2015)

Despite the increasing age and obsolescence of the Class 80, the lack of available rolling stock meant that NIR was forced to retain a number of units, even in spite of the entry into service of the new Class 3000. Until 2011, NIR maintained up to three 4-car units for use on passenger services. These saw a pair of 2-car units, a power car and driving trailer, coupled back to back. Six trailers were refurbished and fitted with central door locking enabling them to remain in service until the new Class 4000 units entered service in 2012. (742 had been nominated for retention but was scrapped in May 2008 and replaced in the programme by 752)

The power cars were overhauled at LH services in Staffordshire and the trailers at York Road works in Belfast

Set 89-733-738-69 remained in service until 24 May 2008

Set 93-754-749-94 was sporadically on test from Wednesday 23 July 2008. From Monday 3 November 2008, regular passenger services commenced with this set.

On 17 December 2009, a second refurbished 80 class was deployed onto the Larne Line. The final sets on the Larne Line were 90-749-752-93 and 94-754-747-82. The third refurbished set was stored at York Road and it consisted of 69-733-738-89. It was rumoured that 82 had been withdrawn from service following from an engine fire. 82 was fixed and returned to working order after the fire in Larne.

On Tuesday 26 January 2010, 89 entered passenger service with 93, 90 was taken off the set on 23 January 2010. 90 was stored at the south end of the south siding at York Road.

Withdrawal from passenger service

In 2011, the entire Class 450 fleet, together with the remaining Class 80 units, was listed by NI Railways for disposal.

The final Class 80 units were withdrawn from passenger service on Sunday 25 September 2011.

Sandite and final withdrawal

97 was converted to a sandite spraying vehicle in 2006 and in 2006 and 2007 was used on these duties coupled to 89. On Wednesday 1 October 2008 97 had a test run with refurbished 82 and this pair were used for sandite trains until December 2008.

In 2009, 97 was on sandite duties again with 82. During October 2009 while out on sandite duties the engine in 97 exploded. 82 struggled with hauling dead 97 so it was decided to add 94 to back of the train to help it along.

Power cars 69+94+90 and driving trailers 749+752 were overhauled, and in 2012, 97 was painted in all-over yellow to help commuters identify it as a non-passenger train. In 2013, 69, 94 and 752 were repainted into all yellow livery to join 97. As part of this repaint, 69 was accidentally renumbered 96.

After the 2014 sandite season, 94 was taken off the set and replaced with 90, which was never repainted into the sandite train's yellow livery. It ran as such for 2015, 2016 and 2017 with the final run taking place on Wednesday 22 November 2017.

All but one of the Sandite vehicles were preserved. The last remaining 80 class vehicle in NIR ownership, 97, is expected to be scrapped in due course.

Preservation

Downpatrick & County Down Railway

An 80 Class at Umbra level crossing in original maroon and blue livery.

On Tuesday 27 March 2018, the Downpatrick and County Down Railway announced it was to preserve four 80 Class vehicles, consisting of power cars 69 and 90, and driving trailers 749 and 752. 69 and 749 have been painted in the original, as-delivered maroon and blue livery. (See photo to right) The fundraising appeal for the campaign can be found on the DCDR's website. In April it emerged that the campaign was endorsed by Pete Waterman, one of the most notable individuals in the world of railway preservation and owner of several locomotives, including at one point No. 4472 ''Flying Scotsman''.

90 and 752 left York Road for the Downpatrick and County Down Railway on 12 May 2018, and 69 and 749 joined them the next day. It is planned that No. 69 will be named ''Mike Collins'' in honour of the railway's former chairman. No. 69 was started for the first time in preservation on 26 May 2018. It ran for the first time under its own power on 23 June 2018, with a series of crew training and platform-gauging runs to Inch Abbey, Downpatrick Loop Platform, and Magnus Grave. Power car No. 90 was similarly started for the first time since it arrived at DCDR, on 7 July 2018. The same day, 69 and 749 entered the main platform at Downpatrick station, completing their gauging trials and thus enabling them to traverse the entire DCDR network. 69 And 749 are expected to make a return to service before the end of 2018, with 90 and 752 being much longer term projects for full restoration.

• DCDR's four 80 Class vehicles
• 
  90
• 
  752
• 
  69
• 
  749

Other

Two other 80 Class vehicles are preserved outside the DCDR. Intermediate trailer 771 was purchased in 2007 by a now-closed B&B in Ballynure, where it remains today. Power car 99 is at the East Lancashire Railway in England, having been purchased for spare parts for 207202. It is currently used as a workshop/storeroom.

Fleet details

Class	Operator	No. in service	Year built	Cars per set	Unit nos.
Class 80	Northern Ireland Railways	0	1974–1979	Varied in service, typically 3 or 4	97 Withdrawn at York Road

Status Of Class 80 Units

	Stored
	Scrapped
	Preserved

Power cars

Number	Status	Notes
67	Scrapped	Was involved in the derailment at Downhill in 2002, after colliding with a rockfall. Scrapped on Monday 6 December 2004.
68	Scrapped	Removed from Adelaide Yard and scrapped on Friday 30 May 2008.
69	Preserved	Underwent refurbishment by LH Services at Barton under Needwood, England. Returned to York Road Works on Friday 18 September 2009. Part of Sandite train. 69 was withdrawn on Friday 9 December 2016 but returned to service during the 2017 sandite season to run along with the new NIR MPV. Final Sandite run took place on Wednesday 22 November 2017. Repainted into their first NIR livery (maroon and blue) for preservation at the Downpatrick & Co. Down Railway since Sunday 13 May 2018.
81	Scrapped	Named The Boys Brigade in 1988. Bomb damaged in 1976 but re-built 2 years later in 1978. Scrapped in January 2006.
82	Scrapped	Badly damaged in the arson attack at Lurgan in Sunday 6 July 1997, but repaired in 1999. Returned after refurbishment by LH Services on Monday 15 September 2008. Returned to passenger service on Thursday 17 December 2009, after spending the last two years exclusively working on sandite duties. Engine block cracked. Scrapped in February 2012.
83	Scrapped	Damaged during 1992, rebuilt the following year in 1993 and finally scrapped on Friday 11 July 2008.
84	Scrapped	Removed from Adelaide and scrapped in 2008
85	Scrapped	Removed from Adelaide and scrapped on Friday 11 July 2008.
86	Scrapped	Named Glendun in 1992. Removed and scrapped on Friday 11 July 2008.
87	Scrapped	Rebuilt in 1979 after being damaged by a bomb at Londonderry. Scrapped in January 2006.
88	Scrapped	Scrapped after an accident at Hilden in 1983. Equipment was re-used in power car 459, to make up the ninth Class 450 set.
89	Scrapped	Refurbished by LH Services at Barton under Needwood, England, and returned to York Road Works on 8 July 2009. Re-entered service on Tuesday 26 January 2010. Engine block cracked. Cut at Ballymena and scrapped at Ahoghill on Thursday 2 February 2017.
90	Preserved	Refurbished by LH Services at Barton under Needwood, England, and returned to Adelaide Yard on Sunday 14 December 2008. Formerly part of Sandite Train. Replaced 94 on the sandite train at the start of the 2015 season. 90 was withdrawn on Friday 9 December 2016 but returned to service during the 2017 sandite season to operate alongside the new NIR Multi-purpose vehicle (MPV). Final Sandite run took place on Wednesday 22 November 2017. Preserved in "Red Bull" livery at Downpatrick and County Down Railway since 12 May 2018.
91	Scrapped	Scrapped Wednesday 28 May 2008.
92	Scrapped	Scrapped during May 2009.
93	Scrapped	Damaged at Finaghy in 1980, but rebuilt the following year in 1981. Returned after refurbishment by LH Services on Monday 12 May 2008. Electrical defect. Scrapped in February 2012.
94	Scrapped	Named Glenariff in 1989. Refurbished; returned on 2 April 2008. This power car was removed from the sandite train at the end of the 2014 season following an engine failure and was replaced by power car No. 90. Cut up at York Road and scrapped at Ahoghill on 11 March 2017.
95	Scrapped	Withdrawn after fire damage on 4 November 2000 and scrapped at Belfast Docks in December 2001.
96	Scrapped	Named Glenshane in 1989. Scrapped in January 2006.
97	Stored	Named Glenshesk in 1990. Suffered irreparable engine damage and was hauled by 2 other power cars as part of the Sandite Unit. Final Sandite run took place on Wednesday 22 November 2017. Expected to be scrapped summer of 2018.
98	Scrapped	Named Glenoe in 1989. Scrapped by Clearways on Wednesday 28 May 2008.
99	Preserved	Named Sir Myles Humphreys in 1978. Damaged in an attack in May 1993, but repaired during 1994. Converted to standard gauge and stored at the East Lancashire Railway in Bury, Greater Manchester, England (intended for spares for other trains)

Intermediate Trailers

Number	Status	Notes
761	Scrapped	Date of scrapping unknown
762	Scrapped	Scrapped on Friday 11 July 2008.
763	Scrapped	Scrapped in May 2009.
764	Scrapped	Removed from Adelaide Yard on Thursday 29 May 2008 and scrapped by Clearways.
765	Scrapped	Removed from Adelaide Yard on Thursday 29 May 2008 and scrapped by Clearways.
766	Scrapped	Scrapped on Friday 11 July 2008.
767	Scrapped	Destroyed by fire.
768	Scrapped	Scrapped on Friday 6 May 2005.
769	Scrapped	Date of scrapping unknown
770	Scrapped	Date of scrapping unknown
771	Preserved	Purchased privately in May 2007 and sited at a Bed and Breakfast near Ballynure (closed 2013).
772	Scrapped	Destroyed by arson on Sunday 6 July 1997.
773	Scrapped	Date of scrapping unknown
774	Scrapped	Scrapped in May 2009.
775	Scrapped	Scrapped in January 2006.
776	Scrapped	Scrapped in May 2009.
777	Scrapped	Scrapped on Friday 6 May 2005.
778	Scrapped	Destroyed by arson on Sunday 6 July 1997.
779	Scrapped	Scrapped on Friday 11 July 2008.
780	Scrapped	Scrapped on Friday 11 July 2008.

Driving Trailers

Number	Status	Notes
731	Scrapped	Date of scrapping unknown
732	Scrapped	Scrapped in January 2006.
733	Scrapped	Refurbishment not completed. Scrapped in February 2012.
734	Scrapped	Scrapped on Wednesday 28 May 2008.
735	Scrapped	Date of scrapping unknown
736	Scrapped	Scrapped on Thursday 29 May 2008.
737	Scrapped	Scrapped after an arson attack on Sunday 6 July 1997.
738	Scrapped	Refurbishment not completed. Scrapped in February 2012.
739	Scrapped	Scrapped in January 2006.
740	Scrapped	Destroyed by fire.
741	Scrapped	Date of scrapping unknown
742	Scrapped	Scrapped by Clearways on Friday 30 May 2008.
743	Scrapped	Scrapped in May 2009.
744	Scrapped	Scrapped on Friday 11 July 2008.
745	Scrapped	Scrapped in May 2009.
746	Scrapped	Date of scrapping unknown
747	Scrapped	Returned to service on Monday 3 November 2008. Scrapped in February 2012.
748	Scrapped	Destroyed in a bomb attack at Crumlin on Friday 25 May 1979.
749	Preserved	Refurbished. Spare but unused driving trailer car for Sandite Train. Repainted by NIR into their original maroon and blue livery for preservation at the Downpatrick & Co. Down Railway since Sunday 13 May 2018.
750	Scrapped	Date of scrapping unknown
751	Scrapped	Destroyed in an arson attack on Sunday 6 July 1997.
752	Preserved	Refurbished. Part of Sandite train until final Sandite run on Wednesday 22 November 2017. Preserved at Downpatrick and County Down Railway in all over yellow livery since 12 May 2018.
753	Scrapped	Removed from Adelaide Yard on Thursday 29 May 2008 and scrapped by Clearways.
754	Scrapped	Refurbished. Stopped on Thursday 16 December 2010. Scrapped in February 2012.
755	Scrapped	Scrapped on Friday 6 May 2005.
756	Scrapped	Scrapped on Friday 6 May 2005.

Gallery

• 
• 
• 
• 
• 
• 
• 
•