Jump to content

Project Nike

From Wikipedia, the free encyclopedia

This is an old revision of this page, as edited by ZDanimal (talk | contribs) at 04:50, 16 November 2012. The present address (URL) is a permanent link to this revision, which may differ significantly from the current revision.

Nike missile family on display at Redstone Arsenal, Alabama. From left, MIM-14 Nike Hercules, MIM-23 Hawk (front), MGM-29 Sergeant (back), LIM-49 Spartan, MGM-31 Pershing, MGM-18 Lacrosse, MIM-3 Nike Ajax.

Project Nike was a U.S. Army project, proposed in May 1945 by Bell Laboratories, to develop a line-of-sight anti-aircraft missile system. The project delivered the United States' first operational anti-aircraft missile system, the Nike Ajax, in 1953. A great number of the technologies and rocket systems used for developing the Nike Ajax were re-used for a number of functions, many of which were given the "Nike" name (after Nike, the goddess of victory from Greek mythology). The missile's first-stage solid rocket booster became the basis for many types of rocket including the Nike Hercules missile and NASA's Nike Smoke rocket, used for upper-atmosphere research.

History

Nike Ajax located in
Marion, Kentucky.

Project Nike began during 1944 when the War Department demanded a new air defense system to combat the new jet aircraft, as existing gun-based systems proved largely incapable of dealing with the speeds and altitudes at which jet aircraft operated. Two proposals were accepted. Bell Laboratories offered Project Nike. A much longer-ranged collision-course system was developed by General Electric, named Project Thumper, eventually delivering the BOMARC missile.

Bell Lab's proposal would have to deal with bombers flying at 500 mph (800 km/h) or more at altitudes of up to 60,000 ft (20,000 m). At these speeds, even a supersonic rocket is no longer fast enough to be simply aimed at the target. The missile must "lead" the target to ensure the target is hit before the missile depletes its fuel. This means that the missile and target cannot be tracked by a single radar, increasing the complexity of the system. One part was well developed. By this point, the US had considerable experience with lead-calculating analog computers, starting with the British Kerrison Predictor and a series of increasingly capable U.S. designs.

For Nike, three radars were used. The acquisition radar searched for a target to be handed over to the Target Tracking Radar (TTR) for tracking. The Missile Tracking Radar (MTR) tracked the missile by way of a transponder, as the missile's radar signature alone was not sufficient. The MTR also commanded the missile by way of pulse-position modulation, the pulses were received, decoded and then amplified back for the MTR to track. Once the tracking radars were locked the system was able to work automatically following launch, barring any unexpected occurrences. The computer compared the two radars' directions, along with information on the speeds and distances, to calculate the intercept point and steer the missile. The entirety of this system was provided by the Bell System's electronics firm, Western Electric.

The Douglas-built missile was a two stage missile using a solid fuel booster stage and a liquid fueled (IRFNA/UDMH) second stage. The missile could reach a maximum speed of 1,000 mph (1,600 km/h), an altitude of 70,000 ft (21 km) and had a range of 25 miles (40 km). The missile contained an unusual three part payload, with explosive fragmentation charges at three points down the length of the missile to help ensure a lethal hit. The missile's limited range was seen by critics as a serious flaw, because it often meant that the missile had to be situated very close to the area it was protecting.

After disputes between the Army and the Air Force (see the Key West Agreement), all longer-range systems were assigned to the Air Force during 1948. They merged their own long-range research with Project Thumper, while the Army continued to develop Nike. During 1950 the Army formed the Army Anti-Aircraft Command (ARAACOM) to operate batteries of anti-aircraft guns and missiles. ARAACOM was renamed the US Army Air Defense Command (USARADCOM) during 1957. It adopted a simpler acronym, ARADCOM, in 1961.

Nike Ajax

A Nike Ajax missile.
Nike site SF-88L missile control.

The first successful Nike test was during November 1951, intercepting a drone B-17 Flying Fortress. The first type, Nike Ajax (MIM-3), were deployed starting in 1953. The Army initially ordered 1,000 missiles and 60 sets of equipment. They were placed to protect strategic and tactical sites within the US. As a last-line of defense from air attack, they were positioned to protect cities as well as military installations. The missile was deployed first at Fort Meade, Maryland during December, 1953. A further 240 launch sites were built up to 1962. They replaced 896 radar-guided anti-aircraft guns, operated by the National Guard or Army to protect certain key sites. This left a handful of 75 mm Skysweeper emplacements as the only anti-aircraft artillery remaining in use by the US. By 1957 the Regular Army AAA units had been replaced by missile battalions. During 1958 the Army National Guard began to replace their guns and adopt the Ajax system.

Each launch site had three parts, separated by at least 1,000 yards (914 m). One part (designated C) of about six acres (24,000 m²) contained the IFC (Integrated Fire Control) radar systems to detect incoming targets (acquisition and target tracking) and direct the missiles (missile tracking), along with the computer systems to plot and direct the intercept. The second part (designated L), around forty acres (160,000 m²), held 1-3 underground missile magazines each serving a group of four launch assemblies and included a safety zone. The site had a crew of 109 officers and men who ran the site continuously. One launcher would be on 15 minutes alert, two on 30 minutes and one on two hour alert. The third part was the administrative area (designated A), which was usually co-located with the IFC and contained the battery headquarters, barracks, mess, recreation hall, and motor pool. The actual configuration of the Nike sites differed depending on geography. Whenever possible the sites were placed on existing military bases or National Guard armories; otherwise land had to be purchased.

The Nike batteries were organized in Defense Areas and placed around population centers and strategic locations such as long-range bomber bases, nuclear plants, and (later) ICBM sites. The Nike sites in a Defense Area formed a circle around these cities and bases. There was no fixed number of Nike batteries in a Defense Area and the actual number of batteries varied from a low of two in the Barksdale AFB Defense Area to a high of 22 in the Chicago Defense Area. In the Continental United States the sites were numbered from 01 to 99 starting at the north and increasing clockwise. The numbers had no relation to actual compass headings, but generally Nike sites numbered 01 to 25 were to the northeast and east, those numbered 26 to 50 were to the southeast and south, those numbered 51 to 75 were to the southwest and west, and those numbered 76 to 99 were to the northwest and north. The Defense Areas in the Continental United States were identified by a one- or two-letter code which were related to the city name. Thus those Nike sites starting with C were in the Chicago Defense Area, those starting with HM were in the Homestead AFB/Miami Defense Area, those starting with NY were in the New York Defense Area, and so forth. As an example Nike Site SF-88L refers to the launcher area (L) of the battery located in the northwestern part (88) of the San Francisco Defense Area (SF).

During the early-to-mid 1960s the Nike Ajax batteries were upgraded to the Hercules system. The new missiles had greater range and destructive power, so about half as many batteries provided the same defensive capability. Regular Army batteries were either upgraded to the Hercules system or decommissioned. Army National Guard units continued to use the Ajax system until 1964, when they too upgraded to Hercules. Eventually, the Regular Army units were replaced by the National Guard as a cost-saving measure, since the Guard units could return to their homes when off duty.

A Nike Ajax missile exploded accidentally at a battery in Leonardo, New Jersey on 22 May 1958, killing 6 soldiers and 4 civilians. A memorial can be found at Fort Hancock in the Sandy Hook Unit of Gateway National Recreation Area.

Nike Hercules

A Nike Hercules missile.
Main article: MIM-14 Nike-Hercules

Even as Nike Ajax was being tested, work started on Nike-B, later renamed Nike Hercules (MIM-14). It improved speed, range and accuracy, and could intercept ballistic missiles. The Hercules had a range of about 100 miles (160 km), a top speed in excess of 3,000 mph (4,800 km/h) and a maximum altitude of around 100,000 ft (30 km). It had solid fuel boost and sustainer rocket motors. The boost phase was four of the Nike Ajax boosters strapped together. In the electronics, some vacuum tubes were replaced with more reliable solid-state components.

The missile also had an optional nuclear warhead to improve the probability of a kill. The W-31 warhead had four variants offering 2, 10, 20 and 30 kiloton yields. The 20 KT version was used in the Hercules system. At sites in the USA the missile almost exclusively carried a nuclear warhead. Sites in foreign nations typically had a mix of high explosive and nuclear warheads. The fire control of the Nike system was also improved with the Hercules and included a surface-to-surface mode which was successfully tested in Alaska. The mode change was accomplished by changing a single plug on the warhead from the "Safe Plug" to "Surface to Air" or "Surface to Surface".

The Nike Hercules was deployed starting in June 1958. First deployed to Chicago, 393 Hercules ground systems were manufactured. By 1960 ARADCOM had 88 Hercules batteries and 174 Ajax batteries, defending 23 zones across 30 states. Peak deployment was in 1963 with 134 Hercules batteries not including the US Army Hercules batteries deployed in Germany, Greece, Greenland, Italy, Korea, Okinawa, Taiwan, and Turkey.

In 1961, SAC and the U.S. Army began a joint training mission with benefits for both parties. SAC needed fresh (simulated) targets which the cities ringed by Nike/Hercules sites provided, and the Army needed LIVE targets to acquire and track with their radar. SAC had many Radar Bomb Scoring (RBS) sites across the country which had very similar acquisition and tracking radar, plus similar computerized plotting boards which were used to record the bomber tracks and bomb release points. Airmen from these sites were assigned TDY to NIKE sites across the country to train the NIKE crews in RBS procedures. The distances from the simulated bomb landing point and the "target" were recorded on paper, measured, encoded, and transmitted to the aircrews. The results of these bomb runs were used to promote or demote air crews. ECM activity also took place between the bombers and the NIKE sites. The performance of the NIKE crews improved remarkably with this "live target" practice.

Many Nike Hercules batteries were manned by Army National Guard troops, with a single active Army officer assigned to each battalion to account for the unit's nuclear warheads. The National Guard air defense units shared responsibility for defense of their assigned area with active Army units in the area, and reported to the active Army chain of command. This is the only known instance of Army National Guard units being equipped with operational nuclear weapons.[citation needed]

Nike Zeus

Launch of a Nike Zeus missile

Development continued, producing Improved Nike Hercules and then Nike Zeus A and B. The Zeus was aimed at intercontinental ballistic missiles (ICBMs).

Zeus, with a new 400,000 lbf (1.78 MN) thrust solid-fuel booster, was first test launched during August 1959 and demonstrated a top speed of 8,000 mph (12,875 km/h). The Nike Zeus system also included the Zeus Acquisition Radar (ZAR), a significant improvement over the Nike Hercules HIPAR system. Shaped like a pyramid, the ZAR featured a Luneburg lens receiver aerial weighing about 1,000 tons. The first successful intercept of an ICBM by Zeus was in 1962, at Kwajalein in the Marshall Islands. Despite its technological advancements, the Department of Defense terminated Zeus development in 1963. The Zeus system, which cost an estimated $15 billion[citation needed], still suffered from several technical flaws, that were believed to be uneconomical to overcome.[1]

Still, the Army continued to develop an anti-ICBM weapon system referred to as "Nike-X" - that was largely based on the technological advances of the Zeus system. Nike-X featured phase-array radars, computer advances, and a missile tolerant of skin temperatures three times those of the Zeus. In September 1967, the Department of Defense announced the deployment of the LIM-49A Spartan missile system, its major elements drawn from Nike X development.

In March 1969. the Army started the Safeguard ABM program, which was designed to defend Minuteman ICBMs, and which was also based on the Nike-X system. It became operational in 1975, but was shut down after just three months.[2]

Decommissioning

Soviet development of ICBMs decreased the value of the Nike (aircraft) air defense system. Beginning around 1965, the number of Nike batteries was reduced. Thule air defense was reduced during 1965 and SAC air base defense during 1966, reducing the number of batteries to 112. Budgetary cuts reduced that number to 87 in 1968, and 82 in 1969.

Some small-scale work to use Nike Zeus as an anti-satellite weapon (ASAT) was carried out from 1962 until the project was canceled in favor of the Thor based Program 437 system during 1966. In the end, neither development would enter service. However, the Nike Zeus system did demonstrate a hit to kill capability against ballistic missiles during the early 1960s. See National Missile Defense and anti-ballistic missile systems.

Nike Hercules was included in SALT I discussions as an ABM. Following the treaty signed during 1972, and further budget reduction, almost all Nike sites in the continental United States were deactivated by April, 1974. Some units remained active until the later part of that decade in a coastal air defense role.

Specifications

Missile Nike Ajax Nike Hercules Nike Zeus A Nike Zeus B (XLIM-49A) Spartan (LIM-49A)
Length 34 ft 0 in (10.36 m) overall
21 ft 0 in (6.41 m)second stage		 41 ft 1 in (12.53 m) overall
26 ft 10 in (8.18 m) second stage		 44 ft 3 in (13.5 m) 48 ft 3 in (14.7 m) 55 ft 1 in (16.8 m)
Diameter 1 ft 0 in (0.30 m) 2 ft 7 in (0.80 m) booster
1 ft 9 in (0.53 m) second stage		 3 ft 0 in (0.91 m) 3 ft 0 in (0.91 m) 3 ft 7 in (1.09 m)
Fin span 4 ft 0 in (1.22 m) 11 ft 6 in (3.50 m) booster
6 ft 2 in (1.88 m) second stage		 9 ft 9 in (2.98 m) 8 ft 0 in (2.44 m) 9 ft 9 in (2.98 m)
Mass 2,460 lb (1,116 kg) at launch
1,153 lb (523 kg) second stage		 10,690 lb (4,850 kg) at launch
5,523 lb (2,505 kg) second stage		 10,980 lb (4,980 kg) 22,700 lb (10,300 kg) 28,900 lb (13,100 kg)
Maximum speed Mach 2.25 (ca. 1485 mph true airspeed @ 50k ft; 2390 km/h) Mach 3.65 (ca. 2094 mph true airspeed @ 65k ft; 3877 km/h) Mach 4 > (ca. 2800+ mph; 4,900 km/h arbitrary)
Range 25 mi (40 km) 87 mi (140 km) 200 mi (320 km) 250 mi (400 km) 460 mi (740 km)
Ceiling 69,900 ft (21,300 m) 149,900 ft (45,700 m) ? 170 mi (280 km) 350 mi (560 km)
First stage Solid-fuel
(59,000 lbf or 263 kN static thrust for 2.5 seconds)		 Hercules M42 solid-fueled rocket cluster
(4x M5E1 Nike boosters)
220,000 lbf (978 kN) total		 Thiokol TX-135
400,000 lbf (1,800 kN)		 Thiokol TX-135
450,000 lbf (2,000 kN)		 Thiokol TX-500
500,000 lbf (2,200 kN)
Second stage Liquid-fuel
(2,600 lbf or 11.6 kN static thrust for 21 seconds)		 Thiokol M30 solid-fueled rocket
10,000 lbf (44.4 kN)		 ? Thiokol TX-238 Thiokol TX-454
Third stage None None None Thiokol TX-239 Thiokol TX-239
Warhead conventional 3 warheads each surrounded with
2 layers of 1⁄4 in (6 mm) hardened steel cubes
Nose: M2: 4.5 lb (2.0 kg) Composition B 12 lb (5.4 kg) total
Mid-body: M3: 92 lb (42 kg) Comp. B, 176.8 lb (80.2 kg) total
Aft: M4: 59 lb (27 kg) Comp B, 121.3 lb (55.0 kg) total		 T-45 HE warhead weighed
1106 lb (500 kg) and contained 600 lb (272 kg) of HBX-6
M17 blast-fragmentation		 Nuclear warhead only Nuclear warhead only Nuclear warhead only
Warhead nuclear Conventional warhead only W-31 nuclear 20 kt (M-22) W-31 nuclear W50 (400 kt)
thermonuclear		 W71 (5 Mt)
thermonuclear

Support vehicles

These trucks and trailers were used with the Nike system.

  • Trucks
M254 truck, missile rocket motor, Nike Ajax
M255 truck, body section, Nike Ajax
M256 truck, inert, Nike Ajax
M257 truck, inert, Nike Ajax
M442 truck, guided missile, rocket motor, Nike Hercules
M451 truck, guided missile test set, Nike Hercules
M473 truck, guided missile body section, Nike Hercules
M489 truck, missile nose section, Nike Hercules
  • G789 Trailers

Deployment

See also: List of Nike missile locations
Locations of US Army Nike Missile Sites within the Continental United States
The remains of former Nike site D-57/58 in Newport, Michigan, USA. At the time this picture was taken in 1996, the site was a hazardous waste cleanup site.
NIKE missile site radar dome with a flock of ravens near Eielson AFB, Alaska.
File:Old NIKE Radar Tower @ Arctic Valley.jpg
NIKE Missile Site near Anchorage, AK

By 1958, the Army deployed nearly 200 Nike Ajax batteries at 40 "Defense Areas" within the United States (including Alaska and Hawaii) in which Project Nike missiles were deployed. Within each Defense Area, a "Ring of Steel" was developed with a series of Nike Integrated Firing and Launch Sites constructed by the Corps of Engineers.

The deployment was designed to initially supplement and then replace gun batteries deployed around the nation's major urban areas and vital military installations. The defense areas consisted of major cities and selected United States Air Force Strategic Air Command bases which were deemed vital to national defense. The original basing strategy projected a central missile assembly point from which missiles would be taken out to prepared above-ground launch racks ringing the defended area. However, the Army discarded this semimobile concept because the system needed to be ready for instantaneous action to fend off a "surprise attack." Instead, a fixed-site scheme was devised.

Due to geographical factors, the placement of Nike batteries differed at each location. Initially, the planners chose fixed sites well away from the defended area and the Corps of Engineers Real Estate Offices began seeking tracts of land in rural areas However, Army planners determined that close-in perimeter sites would provide enhanced firepower. Staggering sites between outskirt and close-in locations to urban areas gave defenders a greater defense-in-depth capability.

Each Nike missile battery was divided into two basic parcels: the Battery Control Area and the Launch Area.

The Battery Control Area contained the radar and computer equipment. Housing and administration buildings, including the mess hall, barracks, and recreation facilities, were sometimes located in a third parcel of land. More likely, however, the housing and administration buildings were located at either the Battery Control Area or the Launch Area, depending upon site configuration, obstructions, and the availability of land.

The Launch Area provided for the maintenance, storage, testing, and firing of the Nike missiles. The selection of this area was primarily influenced by the relatively large amount of land required, its suitability to extensive underground construction, and the need to maintain a clear line-of-sight between the missiles in the Launch Area and the missile-tracking-radar in the Battery Control Area.

The first Nike sites featured above-ground launchers. This quickly changed as land restrictions forced the Army to construct space-saving underground magazines. Capable of hosting 12 Nike Ajax missiles, each magazine had an elevator that lifted the missile to the surface in a horizontal position. Once above ground, the missile could be pushed manually along a railing to a launcher placed parallel to the elevator. Typically, four launchers sat atop the magazine. Near the launchers, a trailer housed the launch control officer and the controls he operated to launch missiles. In addition to the launch control trailer, the launch area contained a generator building with three diesel generators, frequency converters, and missile assembly and maintenance structures.

Because of the larger size of the Nike Hercules, an underground magazine's capacity was reduced to eight missiles. Thus, storage racks, launcher rails, and elevators underwent modification to accept the larger missiles. Two additional features that readily distinguished newly converted sites were the double fence and the kennels housing dogs that patrolled the perimeter between the two fences.

The Nike Hercules was designed to use existing Nike Ajax facilities. With the greater range of the Nike Hercules allowing for wider area coverage, numerous Nike Ajax batteries were permanently deactivated. In addition, sites located further away from target areas were desirable due to the nuclear warheads carried by the missile. Unlike the older Ajax sites, these batteries were placed in locations that optimized the missiles' range and minimized the warhead damage. Nike Hercules batteries at SAC bases and in Hawaii were installed in an outdoor configuration. In Alaska, a unique above-ground shelter configuration was provided for batteries guarding Anchorage and Fairbanks. Local Corps of Engineer Districts supervised the conversion of Nike Ajax batteries and the construction of new Nike Hercules batteries.

Nike missiles remained deployed around strategically important areas within the continental United States until 1974. The Alaskan sites were deactivated in 1978 and Florida sites stood down during the following year. Although the missile left the U.S. inventory, other nations maintained the missiles in their inventories into the early 1990s and sent their soldiers to the United States to conduct live-fire exercises at Fort Bliss, Texas.

Leftover traces of the approximately 265[3] Nike missile bases can still be seen around cities across the country. As the sites were decommissioned they were first offered to federal agencies. Many were already on Army National Guard bases who continued to use the property. Others were offered to state and local governments while others were sold to school districts. The left-overs were offered to private individuals. Thus, many Nike sites are now municipal yards, communications and FAA facilities (the IFC areas), probation camps, and even renovated for use as Airsoft gaming and MilSim training complexes. Several were completely obliterated and turned into parks. Some are now private residences. Only a few remain intact and preserve the history of the Nike project. There are also a few sites abroad, notably in Germany, Turkey and Greece.

Defense areas within the United States were (click on link for more information):

Nike as sounding rocket

The Nike was also used as sounding rocket in the following versions:

Survivors

Bases

  • The best preserved Nike installation is site SF88L located in the Marin Headlands just west of the Golden Gate Bridge in San Francisco, California. The site is a museum, and contains the missile bunkers, and control area, as well as period uniforms and vehicles that would have operated at the site. The site has been preserved in the condition it was in at the time it was decommissioned in 1974. The site began as a Nike Ajax base and was later converted to Nike Hercules. Three Nike Hercules are displayed in the original bunkers. The base is open to the public. Tours are conducted by members of the Golden Gate National Recreation Area staff.
  • The second best preserved Nike installation is site NY-56 at Fort Hancock in Sandy Hook, New Jersey. The site has been restored and contains the original missile bunkers, as well as three Nike Ajax and a Nike Hercules on display. Each fall the base hold a Cold War Day. Tours one weekend a month from April to October. The site is on the National Register of Historic Places.
  • There is also a decommissioned Nike base in Cougar Mountain Regonial Wildlife park, but very little of it remains.[citation needed]

Missiles

Public Display In Everglades

As the 50th anniversary of the Cuban Missile Crisis approaches, a group of students attending the George T. Baker Aviation School are restoring a Nike Hercules missile for display at one of the original launch sites in the Everglades. The missile was salvaged from a US Army depot in Alabama. It will be on public display at HM69 Nike Missile Base, which is operated by the National Park Service.[5]

See also

Sources

  • Morgan, Mark L., & Berhow, Mark A., Rings of Supersonic Steel, Second Edition, Hole in the Head Press, 2002, ISBN 0-615-12012-1.
  • John C. Lonnquest, David F. Winkler (November 1996). To Defend and Deter: The Legacy of the United States Cold War Missile Program (USA-Cerl Special Report, N-97/01,). Afhra. ISBN [[Special:BookSources/978-9996175718|978-9996175718[[Category:Articles with invalid ISBNs]]]]. {{cite book}}: Check |isbn= value: invalid character (help)

References

  1. ^ "NIKE ZEUS - Seventeen years of growth" Flight International 2nd August 1962 pp.166-170
  2. ^ "Missile defences have a long history". Bulletin of the Atomic Scientists. 53. Educational Foundation for Nuclear Science, Inc.: 69 January 1997. ISSN 0096-3402. Retrieved 9 February 2011.
  3. ^ http://www.redstone.army.mil/history/nikesite/sites/summary.pdf
  4. ^ a b c d e Origins of NASA Names. NASA. 1976. p. 133. {{cite book}}: More than one of |pages= and |page= specified (help)
  5. ^ Missile gets makeover on 50th anniversary of Cuban crisis, Yahoo! News, October 13, 2012
Wikimedia Commons has media related to Nike (rocket).

Retrieved from "https://en.wikipedia.org/enwiki/w/index.php?title=Project_Nike&oldid=523275216"